Comparative study of subsurface drip irrigation and flood irrigation systems for quality and yield of sugarcane

Abstract

Subsurface drip irrigation (SDI) is a most advanced method of irrigation that facilitates the irrigation of crop / 
plants with small amounts of water through the T- tapes placed below the soil surface. Depth of T-tape and 
requirement of water depends upon soil type and crop under observations. Experiments for comparative study of 
SDI with flood irrigation for yield and quality were conducted on sugarcane crop from 2005 - 2008 with 3-varieties 
i.e. HSF-240, HS- 12 and CSSG-668 on an area of 6 ha. Drip tapes were buried manually in the middle of the ridges 
on an area of 3 ha with subplot size for each variety of 1 ha compared with flood irrigated crop of 3 ha with 
subplot of 1 ha for each variety. Flood irrigation system showed better results for growth, yield and quality of 
sugarcane than SDI. Germination % and tillers/plant did not show any significant difference under both irrigation 
systems. SDI resulted to lower mill- able cane, cane yield, crop growth rate (CGR) and net assimilation rate 
(NAR). Harvest index % (HI) had no significant effect on both irrigation systems. Higher leaf relative water 
contents (LRWC) obtained under flood irrigation showed higher accumulation of water supplied through flood 
system. Similarly, quality attributes (juice extraction, purity %, recovery % cane and sugar yield t/ha) showed 
superior behavior under flood irrigation than SDI. Flood irrigation system provided net benefits ranging from Rs. 
56130 – Rs. 82760 / ha while SDI resulted in loss from Rs. 127345 to 157910 / ha. Maximum income benefit was 
recorded in CSSG-668 variety (Rs. 82760 / ha) and maximum loss in HSF-240 variety (Rs. 157910 / ha) under SDI. 
SDI helped to save water from 11 - 18% over flood irrigation system that had no significant contribution in net 
benefits. This loss may be due to the major problems faced by SDI system that led to blockage, damaged of T
tapes, filtration obstructions due to high ferrous contents in irrigated water, higher initial cost, management, that 
resulted to net economic loss in sugarcane. Irrigated water was unfit with high ferrous contents that resulted to 
blockage of T -tapes. SDI saved 18% water as compared to flood irrigation system. It was concluded that SDI is 
not a superior system of irrigation for sugarcane in developing countries like Pakistan where water is unfit for 
irrigation. Its high installation cost, breakage and clogging resulted to net economic loss. SDI might be a superior 
system where water is fit for irrigation, free of ferrous and low installation costs.